Browse by: Floors
Lenny's GMC Savannah
Just a cheap carpet from Walmart
Polyisocyanurate Laminated Sheets, then plywood
- Bunnings 17mm structural ply
Link: jazmorton.com/van-conversion/insulation-floor/
Ian and Kate's 1996 Dodge B1500 Ram
Birch laminate over plywood.
Daniel's 2016 Mercedes Benz Sprinter
Snap and click vinyl flooring
Mike's School bus
Foam board insulation with timber overlay.
ExpeditionEvans's 2002 Ford E-450 Dually
Hardwood laminate flooring throughout (graciously given to us!)
Grant's 2017 Mercedes Benz Sprinter
3/4" Foam Insulation under factory floor, stick on vinyl flooring over
Glenn's Mercedes Benz 608D
Reflective bubble insulation under plywood with Ronseal exterior varnish
Link: glennjobson.co.uk/fire-engine-camper-fitting-new-f...
Java230's 2008 Ford F450 4x4
Foam underlay. Vinyl planks from Lowes over insulating foam underlay
Link: nwadventuretruck.com/flooring-a-real-change-to-the...
I love wooden floors and from very start of my project i decided that my floor will be wooden no matter what. I choose hardwood floor for total 180 euros.
Soft cork floors.
Standard carpet and mats
Sam's Mercedes Benz Sprinter
Faux timber vinyl
Alpine Margarita's Dodge Promaster
Rattle trap, timber strips, foam board, plywood, click vinyl flooring.
- Click vinyl flooring
Would NOT recommend. It was a pain and has definitely shifted/popped up in spots. If we did it again we’d use a single piece of sheet vinyl. - FatMat Self-Adhesive RattleTrap Sound Deadener
- DOW Super TUFF-R foam board insulation
ElPollo_Crazy's 2015 Transit Connect
Reflectix under carpet.
Mark's 2010 Mercedes Benz Sprinter
Initially 15mm ply, but later replaced with 9mm. Original weight was too high. Vinyl floor tiles. Easy to lay and easy to clean.
Link: stealthsprinter.com/van-build/miscl/
Adam Sloan's 2005 Ford Windstar
Vinyl over 1/4" plywood subfloor.
Elliot's 2004 Dodge Sprinter 2500 High Top 140"
Aluminized styrofoam; 2 sheets required. Home depot vinyl roll $50, oem plywood underneath (not fastened to anything), rivet holes in floor epoxied and caulked, fuel lift pump access door. Details in YouTube video below.
Aiden, Shauna and Beetlejuice's 2010 Iveco Daily
25mm Celotex Boards, 25mm Roofing Battens, Plywood Underfloor, Vinyl Flooring.
Sound deadening material, then vinyl over polyiso board and insulating foam. We chose step trims and carpet trim to finish.
Link: simplehike.wordpress.com/2017/07/04/van-flooring/
Pib and Stef's 2001 Mercedes Benz Sprinter
Sealed with resin/fiberglass. Then 20mm extruded polystyrene foam boards.
Tony's 2004 Chevrolet Express 3500
The floors have 3/4" hard foam insulation and a 1/2" plywood sub-floor. The sub-floor was screwed into the chassis with 1.5" stainless steel lag screws, which were counter sunk into the wood. Then a layer of wood filler and one foot square vinyl tiles.
Vinyl planks glued on.
Rob & Emily's 2008 Mercedes Benz Sprinter
Solid oak flooring. its heavy and expensive but total luxury!
Justin & Olivia's 1984 Dodge B250
Peel and stick laminate on 30+ year old wood
Tali and Rock's 2016 Ford Transit T150
Stock Cargo Mat
Nick & Beth's 2018 Ford Transit 250 High Roof
Polyiso foam board insulation, 1/2" plywood sub floor and click-lock vinyl flooring
I installed sound and heat insulation in the entire floor of the Jeep, then covered it with lino for durability.
- Dynamat 10455 Self-Adhesive Sound Deadener with Xtreme
Link: theroadchoseme.com/jeep-build-phase-1-complete
Nick's 2003 Ford Econoline E150
Vinyl attached with glue.
Ian's 1994 Ambulance
1/2in solid Teak TnG floorboards.
